key: cord-0997187-pu85hbgk
authors: Mariita, Richard M.; Wilson Miller, Amy C.; Randive, Rajul V.
title: Evaluation of the virucidal efficacy of Klaran UVC LEDs against surface-dried norovirus
date: 2022-01-12
journal: Access Microbiol
DOI: 10.1099/acmi.0.000323
sha: 86f9adcaad432bcd169f2cf4f4311be016342c54
doc_id: 997187
cord_uid: pu85hbgk

Human norovirus (HuNoV) is a highly contagious pathogenic virus that is transmitted through contaminated food, water, high-touch surfaces and aerosols. Globally, there are an estimated 685 million infections annually due to norovirus, including 200 million affecting children under the age of 5. HuNoV causes approximately 50, 000 child deaths per year and costs an estimated USD $60 billion annually in healthcare. This study sought to determine the inactivation profile of ultraviolet subtype C (UVC) against norovirus using a UVC light-emitting diode (LED) array, KL265-50V-SM-WD. The array emitted radiation at 269 nm peak wavelength and a measured fluence of 1.25 mW cm(−2) at a 7 cm source–surface distance. Since the HuNoV is not cultivable, the study utilized feline calicivirus (FCV) ATCC VR-782, a recommended surrogate as challenge organism. The test followed modified ASTM E2197. Assessment of virus inactivation was performed using a plaque assay method. With irradiance at a UVC dose of 22.5 mJ cm(−2), the study obtained 99.9 % virus reduction (3 log reduction). The results demonstrate that the UVC LED array can provide effective inactivation of HuNoV.

Human norovirus (HuNoV), formerly known as Norwalk virus, is an RNA virus belonging to the family Caliciviridae [1] . This is a highly contagious, small, non-enveloped enteric pathogen that is transmitted through person-to-person contact and unsanitary food handling [2] , contaminated water and high-touch surfaces [1] , and can also be spread via aerosols [3] . Because it only requires a small inoculum to produce an infection (<100 viral particles), is pathogenic and has the ability to survive in different environments, HuNoV is responsible for substantial comorbidity, especially in healthcare and community settings [1] , such as daycare centres, nursing homes, hospital wards, schools, restaurants, catered events and cruise ships [4] .

Globally, there are an estimated 685 million cases of norovirus infections annually, with ~200 million of them being among children under 5 years old, leading to an estimated 50, 000 child deaths and healthcare costs estimated at USD $60 billion per year [5] . In the USA, HuNoV is associated with 80-90 % of the reported outbreaks and is the leading cause of nonbacterial gastroenteritis [4] . On average, in the USA, HuNoV causes an average of 570-800 deaths, 56, 000-71, 000 hospitalizations, 400, 000 ER visits, 1.7-1.9 million outpatient visits and 19-21 million total illnesses per year [6] . Outbreaks involve people in high-risk groups, particularly young children under 5 years of age, the elderly above 65 [6] , travellers, soldiers and the immunocompromised [4] . To compound the problem, only a limited number of disinfectants are effective against HuNoV has at present [7] . Unlike with other viral pathogens, such as severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) [8] , vaccine design and production efforts against HuNoV have not been successful. Study of HuNoV has further been hindered by the inability to propagate it in cell cultures [9] . Because of this, another virus from the family Caliciviridae, feline calicivirus (FCV), is frequently used as a surrogate [10] , especially in determining the virucidal efficacy of disinfectants [7] .

For RNA viruses, ultraviolet subtype C (UVC) induces inactivation that leads to RNA damage [11] , the principal factor in loss of viral infectivity [12] , while FCV is thought to be a reasonable surrogate for HuNoV UVC inactivation profiles. Light-emitting diodes (LEDs) made from semiconductor materials can be used to produce UVC in the range of 200-280 nm [13] , which is considered to be germicidal [14] . LEDs emitting UVC have been used in agriculture, water and the food industry for microbial OPEN ACCESS inactivation because they have several advantages over conventional sources [13] . Such advantages include compact size that makes incorporation easier, being nonhazardous (no health hazards due to the possibility of mercury contamination), showing high performance and having a long lifetime [13] .

The inactivation of HuNoV is a major focus in water purification [15] . This is because of the existing economic and public burden associated with HuNoV, thus there is a need for additional appropriate interventions, including effective inactivation strategies. Here, the study utilized a disinfection assay to investigate the virucidal activity of a UVC LED array (KL265-50V-SM-WD) against FCV ATCC VR-782 on magnetic stainless steel discs. Steel coupons were used because human norovirus transmission can be via contaminated surfaces (fomites) [12] . The aim of the study was to determine the inactivation profile of a UVC LED array with peak emission of 269 nm against norovirus.

A USB4000 photospectrometer (Ocean Optics) was used to confirm the emitted radiation peak wavelength of the UVC LED array. For UVC dose, confirmation was achieved using the X1 handheld optometer (Gigahertz-Optik). The UVC LED array tested in this study was KL265-50V-SM-WD, which is rated between 70-80 mW at 500 mA and was driven at 350 mA, yielding an expected 56-64 mW at beginning of life.

The disinfection assay was carried out using Eagle's modified medium with 2 % fetal bovine serum (FBS) as the test solution. The virus was applied on 20 mm diameter magnetic stainless steel discs, spread and dried at room temperature prior to exposure to UVC. The sample was put in the centre of the box, directly opposite and aligned to the light source, where maximum intensity is found. The distance between the LED and microbe was fixed at 7 cm.

The inactivation experiments were performed in duplicate per irradiation period using feline calicivirus (FCV) ATCC VR-782 spread on stainless steel magnetic discs following a modified ASTM E2197: Standard Quantitative Disk Carrier Test Method [16] . Specifically, this was done by applying 32 µl of standardized FCV on each disc, spreading to within 1 mm of the edges, and then air drying at room temperature. The stainless steel magnetic discs were then irradiated for 12, 18 and 22 s prior to suspension in 10 ml modified SCDLP (soybean, casein digest agar with lecithin and polysorbate) medium for virus recovery. SCDLP buffer was modified by having the formulation without lecithin or polysorbate 80. Additionally, 0.1 % bovine serum albumin was added as a stabilizing solution and 1× penicillin-streptomycin antibiotics was added to inhibit bacterial contamination of cell cultures.

To quantify viable viral particles, the dilution plate method was followed, with Crandell-Rees feline kidney (CRFK) ATCC CCL-94 cell lines being used for growth [17] . Viral particles were determined using crystal violet for staining to enable visualization of plaques for counting, giving plaque-forming units (p.f.u.) [18] . Mean p.f.u. between controls and irradiated samples were then used to calculate reduction following the formula:

where A=p.f.u./disc for control (no irradiation with UVC) and B=p.f.u./disc for UVC ON at a given irradiation period in seconds.

The confirmed peak wavelength of the UVC array was 269 nm, and at 7 cm height (Fig. 1) it obtained an intensity of 1.25 mW cm −2 . At 12 s and a dose of 15 mJ cm −2 , the LED array obtained a 2.70 log reduction of viable FCV virus (Table 1 ). At 18 s or more (22.5 mJ cm −2 or higher dose), a >3 log reduction of viable FCV virus was obtained. No inactivation differences at 18 and 22 s (22.5 and 27.5 mJ cm −2 ) of irradiation were revealed ( Table 1 ). The experiment were performed in duplicate (intra-experimental repeats). The exhibited virucidal activity against FCV suspensions air dried on stainless steel magnetic discs is promising because surfaces are vectors of HuNoV transmission during outbreaks [19] .

These results are specific to 269 nm against FCV, the commonly used HuNoV model organism. Although the spectral sensitivity of HuNoV has not been investigated, it should be expected that different wavelengths will perform differently against viral pathogens, even with the same dose [20] . In coronaviruses for instance, a study by Gerchman et al., [20] demonstrated that UVC LEDs emitting radiation at peak wavelength between 267 and 279 nm were more effective at inactivation. A similar approach, however, should be utilized to confirm performance against HuNoV so as to determine sensitivities. Previously, investigations using UV 254 , a commonly used disinfection process in the water industry, established an inactivation rate constant for HuNoV [15] . Such an approach should be utilized in future studies with other UVC LEDs with different peak emissions to enable sensitivity comparisons against other surrogates.

The findings from the current study demonstrate the potential application of KL265-50V-SM-WD UVC arrays in cruise ships and resorts, especially living and dining quarters, where there are high risks of HuNoV acquisition, which can lead to disease outbreaks [21] . With necessary radiation safety considerations, results can further be applied in other areas of close living quarters or with shared dining facilities to help disrupt viral transmission [1] . Such areas include those that have reported norovirus outbreaks, such as schools [22] , military training centres and fields of operation [23] , healthcare facilities [24] and the restaurant and catering industry [25] , as well as municipal and industrial water systems [26] .

In this study, a 22.5 mJ cm −2 UVC dose was found to be sufficient to achieve a >3 log reduction against FCV. The use of UVC LEDs thus promises a reduction of virus transmission during outbreaks. These findings demonstrated that UVC LEDs could serve as an effective and rapid tool in the fight against human norovirus by preventing spread via fomites.

The original laboratory report with data is available upon request.

This work received no specific grant from any funding agency. Table 1 . Inactivation performance of an array (KL265-50V-SM-WD) emitting UVC radiation at 269 nm peak wavelength with intensity of 1.25 mW cm −2 revealed no inactivation differences at 18 and 22 s of irradiation. A dose of 22.5 mJ cm −2 was enough to obtain a >3 log reduction. All experiments were performed in duplicate (intra-experimental repeats) and means were used for inactivation efficacy determination 

Critical review on the public health impact of norovirus contamination in shellfish and the environment: A UK Perspective

Aerosol transmission of infectious disease

Norovirus gastroenteritis

Norovirus disease in the United States

Virucidal efficacy of disinfectant actives against feline calicivirus, a surrogate for norovirus, in a short contact time

SARS-CoV-2, the other face to SARS-CoV and MERS-CoV: Future predictions

The makings of a good human norovirus surrogate

Efficacy of three ethanol-based hand rubs against feline calicivirus, a surrogate virus for norovirus

Comparison of UV-induced inactivation and RNA damage in MS2 Phage across the Germicidal UV Spectrum

Ultraviolet light inactivation of murine norovirus and human norovirus GII: PCR may overestimate the persistence of noroviruses even when combined with Pre-PCR treatments

Applications of Light-Emitting Diodes (LEDs) in food processing and water treatment

Recent advances on the application of UV-LED technology for microbial inactivation: Progress and mechanism

UV disinfection of human norovirus: evaluating infectivity using a genomewide PCR-based approach

Antimicrobial Testing Methods & Procedures: MB-31-03. Standard Operating Procedure

Antibodies against Crandell Rees feline kidney (CRFK) cell line antigens, alpha-enolase, and annexin A2 in vaccinated and CRFK hyperinoculated cats

Two detailed plaque assay protocols for the quantification of infectious SARS-CoV-2

Virucidal activity of a quaternary ammonium compound disinfectant against feline calicivirus: a surrogate for norovirus

UV-LED disinfection of Coronavirus: Wavelength effect

Disease transmission and passenger behaviors during a high morbidity Norovirus outbreak on a cruise ship

Norovirus outbreak in an elementary school--District of Columbia

Norwalk-like virus infection in military forces: epidemic potential, sporadic disease, and the future direction of prevention and control efforts

Impact of an outbreak of norovirus infection on hospital resources

A foodborne outbreak due to norovirus in Austria

Gastroenteritis due to Norwalk virus: an outbreak associated with a municipal water system

The authors thank Dr Kevin Kahn, James Davis and Michelle Lottridge for their help with review of the manuscript. The authors also thank the ResInnova Laboratories (Silver Spring, MD, USA), an International Antimicrobial Council (IAC) certified laboratory for utilizing their virology capabilities in the norovirus experiments for Crystal IS.Author contributions R.M.M. contributed to study design, analyzedanalysed and interpreted data, and was a substantial contributor in writing the manuscript. A.C.W.M. was a substantial contributor to the study design and coordinated research efforts. R.V.R. was a substantial contributor to the study design and ensured the provision of study materials. All authors read, revised and approved the final manuscript.Conflicts of interest R.M.M., A.C.W.M. and R.V.R. work for Crystal IS, an Asahi Kasei company that manufactures UVC LEDs.

Five reasons to publish your next article with a Microbiology Society journal 1 . The Microbiology Society is a not-for-profit organization. 2. We offer fast and rigorous peer review -average time to first decision is 4-6 weeks. 3. Our journals have a global readership with subscriptions held in research institutions around the world. 4. 80% of our authors rate our submission process as 'excellent' or 'very good'. 5. Your article will be published on an interactive journal platform with advanced metrics.Find out more and submit your article at microbiologyresearch.org.