key: cord-0914218-92hm6gx6 authors: Annamaria, Petrungaro; Eugenia, Quartarone; Paolo, Sciarrone title: Anti-SARS-CoV-2 hyperimmune plasma workflow date: 2020-06-10 journal: Transfus Apher Sci DOI: 10.1016/j.transci.2020.102850 sha: 5c89437d1e8bb368a24d1de7eccd404bcec381c6 doc_id: 914218 cord_uid: 92hm6gx6 Coronavirus disease 2019 (COVID-19) caused by the novel coronavirus has become a Public Health Emergency of International Concern. Among the various treatment proposals for COVID-19 infection, passive immunotherapy using plasma from recovering patients - "convalescent plasma" (CP )- could be a promising option in the treatment of SARS-CoV-2 infections. Immune (i.e. "convalescent") plasma refers to plasma that is collected from individuals, following resolution of infection and development of antibodies. Passive antibody administration through transfusion of convalescent plasma may offer the only short-term strategy to confer immediate immunity to susceptible individuals. According to the World Health Organization (WHO), the use of plasma therapy is permitted when faced with «serious diseases for which there are no effective pharmacological treatments». Several clinical trials are underway to test the effectiveness of hyperimmune plasma at various stages of SARS-CoV2.The Food and Drug Administration (FDA), the U.S. regulatory authority, has approved the use of CP for compassionate use in the treatment of patients with a critical COVID-19 infection. Below are the general indications for drawing up clinical protocols for the integral management of "COVID-19-convalescent plasma" for which the validation and approval of the Ethics Committees is still necessary. worsening of the condition of patients with active phase infection. Plasma infusions for convalescents are a method already used and authorized by the World Health Organization ( WHO) to treat a range of diseases, such as polio, measles, mumps, Ebola, SARS, Mers and H1N1.The used therapy protocols differ in the following aspects: dosage, antibody titer and timing of administration (Table 1) .CP contains antibodies, which could be valuable in fighting COVID-19 infection 5, 6 .According to the WHO, the use of plasma therapy is permitted when faced with «serious diseases for which there are no effective pharmacological treatments». Several clinical trials are underway to test the effectiveness of hyperimmune plasma at various stages of SARS-CoV2.The Food and Drug Administration (FDA),the U.S.regulatory authority, has approved the use of CP for compassionate use in the treatment of patients with a critical COVID-19 infection.It has now become necessary to start controlled and randomized clinical trials to consolidate the data obtained from the sporadic clinical experiences. Below are the general indications for drawing up clinical protocols for the integral management of "COVID-19-convalescent plasma" for which the validation and approval of the Ethics Committees is still necessary. Currently amenable immunotherapy modes can be divided into two types: passive and active.The active type strengthens the immune system's response to various pathogenic attacks by activating both humoral immunity and cell-mediated immunity, using the adaptive response. Passive antibody therapy involves the administration of antibodies against a given agent to a susceptible individual obtained from Convalescent Plasma (CP) from subjects who have recovered from an infection, monoclonal antibodies (mAbs),or preparations generated by pharmaceutical company producing purified preparations containing a high titer of neutralizing antibodies 42 .Passive immunotherapy can prevent the clinical development of the infection or reduce the severity of the infection in those subjects recently exposed to various pathogens. Its effectiveness is higher if administered for preventive purposes or at an early stage from the onset of the symptoms 7,8. A further use of CP is the development of a polyclonal "hyperimmune globulin" concentrate obtained from a pool of plasma donors called "hyperimmune plasma ",collected through apheresis from patients treated after an infection and who have developed high serum titers of neutralizing antibodies 43 . During plasma apheresis of SARS-Cov-2 healed donors, in addition to neutralizing antibodies (NAbs), other proteins such as anti-inflammatory cytokines, coagulation factors, antibodies, defensins, pentraxins and other undefined proteins are collected 8 .Therefore, CP transfusion has an immunomodulatory action improving the J o u r n a l P r e -p r o o f severe inflammatory response triggered by the infection 9 .In Sars-CoV-2 an excessive activation of the immune system with the development of a systemic hyperinflammation or " cytokine storm " linked to the release of IL-1β, IL-2, IL-6, IL-17, IL-8, TNF and CCL-2 has been shown;this framework determines the development of a Systemic Inflammatory Response Syndrome (SIRS) with enhanced damage on pulmonary ventilatory capacity that results in severe fibrosis 10,11 . In patients with COVID-19 disease it is possible to observe an initial antibody response "early" and a delayed antibody response "late" 20 . "Early" antibodies are mainly anti Spike protein (Ab-S) and enhance virus induced apoptosis; "late" antibodies are mainly anti nucleocapsid (Ab-N) and have a neutralizing action 21, 22 .It is of considerable interest that serum conversion in COVID 19 + patients occurs 12 days after infection but is not followed by rapid decline in viral load 23 . Such evidence is consistent with the finding of a non-optimal initial endogenous antibody response. Therefore, overall, these results suggest that the absence of reported serious adverse effects associated with hyperimmune plasma infusion may be, at least in part, related to the different quality of antibodies in convalescent patients at different stages of the disease. For this reason, both a proper evaluation of the antibody response in convalescent patients and an adequate titer of neutralizing SARS-CoV-2 antibodies present in the collected plasma are essential. The peak of IgG anti-Sars-CoV-2 and neutralizing antibodies is detectable up to approximately 4 months, after which there is a decline of up to 25-6% IgG antibodies and 16-1% Neutralizing antibodies in 36 months 24 .The average antibody titer of neutralizing antibodies 1/60 (1/12 to 1/512) is almost similar to day + 35 and + 180 from the onset of infection symptoms 25, 26 . In addition, the antibody level in convalescent patients has been correlated with the initial viral load and independently associated with the severity of the disease in both H1N1+ and MERS-CoV+ patients 27, 28 .For such evidence it would be preferable to collect the plasma of convalescent patients from a significant Sars-CoV-2 disease. Candidates for hyperimmune plasma donation are individuals with documented SARS-CoV-2 infection who voluntarily and in an informed manner adhere to plasma apheresis donation dedicated to the therapy of complicated SARS-CoV-2 infections. In addition,they must have recently recovered from COVID-19 and have been previously hospitalized. This also includes asymptomatic individuals in fiduciary quarantine at home and under active supervision following a positive test, provided that they meet the following eligibility criteria:  age between 18-and 65-years old weight not < 50 Kg 12,13 ; J o u r n a l P r e -p r o o f  at least 14 days after clinical recovery (resolution of symptoms) and negative documentation of two Nucleic Acid Tests (NAT) on nasopharyngeal swab and Reverse transcriptase-polymerase chain reaction (RT-PCR) plasma/serum performed 24 hours apart immediately prior to patient discharge (if hospitalised);  possible documentation of negativity of a NAT test on nasopharyngeal swab and RT-PCR plasma/serum 14 days after recovery (if in fiduciary quarantine) (request not common to all protocols examined);  negativity to testing for Covid-19 repeated at donation timing and after 48 hours;  appropriate serum titer of specific antibodies (> 160 by Enzyme Immunoassay (EIA) or equivalent value by other method, based on other published case studies 14, 15, 16 ;  absence of Human Leukocyte Antigen (HLA) antibodies. It is recommended to verify the absence of Sars-Cov2 Rna on plasma collected by RT-PCR 17 .This target population provides for the collection of a blood component with some exceptions to the standards defined by the selection criteria of Ministerial Decree( MD) 2.11.2015. 18 These exceptions may concern the age of the donor, a short clinical recovery interval (less than twice the incubation period, as recommended by the "Guide for the preparation, use and quality assurance of blood components" published by the Council of Europe -EDQM) 19 and the clinical use of donors not previously tested and therefore without a previous sampling history that qualifies their safety profile. On the other hand, the other criteria for the selection of the donor referred to in the mentioned of MD 2.11.2015 must be respected,especially the exclusion of individuals undergoing transfusion therapy and/or with previous pregnancies.In addition to these convalescent patients,regular blood donors should be considered if the specific antibody titer in their serum is >160 by EIA (or equivalent value by another method), these persons fall into the category of donors that can be used for the production of hyperimmune plasma because: -they already meet the requirements of regular blood donors 18 ; -a time equal to or greater than twice the incubation period (i.e. at least 28 days) has elapsed since the clinical recovery of the disease, as recommended by the "Guide for the preparation, use and quality assurance of blood components" published by the Council of Europe -EDQM 19 . Apheresis is a recommended procedure for obtaining plasma. This procedure is based on continuous centrifugation of whole blood with separation and collection of plasma. The effectiveness of this technique is to obtain about 400-800 mL of plasma from single aphaeretic donation. The Transfusion Service has premises suitable for the intended use, in order to limit the risk of errors, as well as cleaning and maintenance operations to minimize the risk of contamination. For apheresis activities, cellular separators must be used (e.g.in total we have two cellular separators) with performance characteristics that guarantee the highest degree of safety for the donor, as well as the quality of the final products, by meeting the requirements for the collection of apheresis hemocomponents as provided for by the current legislation. For the sealing of the connection circuits of the sampling systems we have soldering systems suitable to prevent the risk of microbial contamination during the collection and production of blood components and we are in possession of a device designed to freeze the plasma produced, to ensure compliance with the specifications defined by the regulations in force. The collected plasma units will be subjected to the biological qualification tests provided for by MD 2/11/2015 and therefore must be negative for the following viral markers: -HBV-HIV-HCV serology and molecular, Syphilis serology 18 . As this is convalescent plasma from non-periodic donors, HAV and Parvovirus B19-DNA (<105 copies/ml) tests must also be performed. -the content of Immunoglobulins (IgG, IgM, IgA), -the specific antibody titer (by EIA must be >160 or equivalent by another method) 48 . The effectiveness of this therapy has been associated with the concentration of neutralizing Ab in the plasma of donors 33 . Solvent/detergent (S/D) treatment for viral plasma inactivation is a matter of discussion 4,40 of literature data, as the treatment is not effective for encapsulated viruses such as HAV and Parvovirus B19 and therefore the procedure is not mandatory. Blood transfusion services should adapt their serum banks to the storage of sera, while requesting the informed consent of donors, allowing for subsequent epidemiological investigations of the blood donor population (Figure 1 ). Hyperimmune plasma has, as already reported in the background, been successfully used in previous coronavirus epidemics:Sars-1 in 2003 and MERS in 2012 29 .In this Covid-19 epidemic there are several reports in which this therapy has been used successfully [30] [31] [32] .The results suggest that the administration of plasma to convalescents is safe, reduces the viral load and improves the clinical course 4 ( Table 1) .Controlled clinical trials are necessary to define the most suitable treatment protocols in the various stages of Covid-19 infection, to test the safety and effectiveness of this passive immunotherapy. Based on Chinese reports, the use of high-dose intravenous immunoglobulins (Ivig-HD) also seems promising; however, the obtained data are few and therefore confusing. The use for prophylactic purposes is not allowed. The eligibility criteria are as follows:  COVID-19 infection confirmed with NAT on nasopharyngeal swab and RT-PCR plasma/serum.  Severe or life-threatening Covid disease: o Severe illness is manifested with one or more of the following symptoms:  dyspnea,  respiratory rate≥ 30/min,  SpO2 ≤ 93%,  partial pressure of arterial oxygen to fraction of inspired oxygen ratio < 300, PaO2/FiO2 <300 mm Hg in oxygen,  lung infiltrates > 50% within 24 -48 hours after infection o Life-threatening disease is defined by one or more of the following symptoms:  Respiratory failure,  Septic shock,  Multi-organ failure (MOF)  Informed consent of the patient or legal guardian.  Positive PCR with seronegativity 35 . The volume and posology of administration of hyperimmune plasma are variable and anecdotal because they are based on clinical experience gained in previous epidemics and comparison with Chinese clinical trials on patients affected by Sars-Cov-2 32 . Based on the Sars-Cov-1studies,therapeutic hyperimmune plasma was used at a dosage of 5 ml/kg with an Ab neutralizing titer of 1: 160 16 . It should also be considered that 3.125/mL kg of plasma have an antibody titer >1.64, therefore 5 ml/kg of plasma corresponds to a titer of hyperimmune globulins 1:160. If we consider a typical patient of about 80 Kg the volume of plasma to infuse will be 250 ml (3.125ml/kg x 80 Kg = 250 ml > 1.64 31 ). The timing and therapeutic dosage to be used according to the various clinical experiences is as follows: 250-300 ml of hyperimmune plasma administered to each of the admitted patients for a maximum of 3 times within 5 days 32 . The maximum administered volume must not exceed 600 ml as the use of higher volumes of plasma would be contraindicated due to the risk of overload. Timely administration is strongly recommended, it is optimal in the first 7 days, good efficacy within 14 days,certainly not indicated beyond three weeks after the onset of the disease. It is important to carry out the therapy during the viral replication phase 31-34 . The possible synergistic associations or advantages of this product compared to the simultaneous use of other drugs are not defined or studied. In the absence of such data, the product should be assigned on the basis of the approved clinical protocol. Passive immunotherapy, according to studies conducted on Ebola virus and Mers-Cov, does not involve severe adverse events except in 2% of cases in the form of Transfusion related acute lung injury (TRALI). In most cases mild adverse events were found in 8% of patients treated, 5% of whom had a febrile reaction and 4% an urticarial reaction [28] [29] [30] [31] [32] [33] [34] [35] . Studies performed on animal models (Rhesus Macaques) have highlighted the risk of antibody-dependent enhancement (ADE).Rhesus Macaques immunized with vaccines containing Covid-19 Spike protein develop a high anti-Spike protein titer; it has been noted that infection with Sars-Cov -2 of these guinea pigs causes severe lung damage (severe acute lung injury-ALI),compared to non-immunized controls, despite a low viral load 21 . This phenomenon is likely linked to early seroconversion prior to virus clearance at lung level with an enhancement of macrophage dependent inflammatory damage by these non-neutralizing antibodies. The tendency to ADE could be genetically determined, therefore in these clinical trials on hyperimmune plasma, a small unknown percentage of genetically susceptible patients could develop a worsening paradoxical symptomatology [37] [38] . Finally, this product is subject to all precautions regarding undesirable effects and contraindications common to human plasma therapy; these include in particular: -the absolute contraindication to its administration in complete IgA deficits, (which is why the dosage of IgA is advised before the onset of therapy) -caution against circulatory overload (TACO) 39 . Hyperimmune plasma is a possible and powerful weapon against Sars-Cov-2 by Covid -19.Further thorough studies are needed to test its safety and the efficacy to make the best use of convalescent plasma on an appropriate patient target. All Authors contributed equally to the study The Authors declare no conflicts of interest. This article was not funded. The authors have no other relevant affiliations orfinancial involvement with any organization or entity with a financial interest in or financial conflict with the subject matter or materials discussed in the manuscript apart from those disclosed. Genomic characterization and epidemiology of 2019 novel coronavirus: implications for virus originsand receptor binding Advances in clinical diagnosis and treatmentof severe acute respiratory syndrome Isolation of a novel coronavirus from a man with pneumonia in Saudi Arabia Convalescent plasma as a potential therapy for COVID-19 Retrospective comparison of convalescent plasma with continuing high-dose methylprednisolone treatment in SARS patients The Effectiveness of Convalescent Plasma and HyperimmuneImmunoglobulin for the Treatment of Severe Acute Respiratory Infections of Viral Etiology: ASystematic Review and Exploratory Meta-analysis Antibody-mediated regulation of cellular immunity and the inflammatory response Plasma therapy against infectious pathogens, as of yesterday, today andtomorrow Intravenous immunoglobulinin neurology--mode of action and clinical efficacy The Role ofCytokines including Interleukin-6 in COVID-19 induced Pneumonia andMacrophage Activation Syndrome-Like Disease Characteristics of lymphocyte subsets and cytokines in peripheral blood of 123 hospitalized patients with 2019 novel coronavirus pneumonia (NCP) MedRxiv Effectiveness ofconvalescent plasma therapy in severe COVID-19 patients Collecting and evaluating convalescent plasma forCOVID-19 treatment: why and how Experience with empirical treatment of severe acute respiratory syndrome due to coronavirus, genotype IVAntibiot Khimioter Feasibility, safety, clinical, and laboratory effects of convalescent plasma therapy forpatients with Middle East respiratory syndrome coronavirus infection: a study protocol Use of convalescent plasma therapy in SARS patients in HongKong Positive RT-PCR Test Results in Patients Recovered From COVID-19 Disposizioni relative ai requisiti di qualita' e sicurezza del sangue e degli emocomponenti European Directorate for the Quality of Medicines & HealthCare (EDQM) Council of Europe. Guide to the preparation, use and quality assurance of blood components Antibody-dependent SARS coronavirus infection is mediated by antibodies against spike proteins Anti-spike IgG causes severe acute lung injury byskewing macrophage responses during acute SARS-CoV infection Immunodominant SARS Coronavirus Epitopes in Humans Elicited bothEnhancing and Neutralizing Effects onInfection in Non-human Primates Clinical presentation and virological assessment of hospitalized cases of coronavirus disease 2019 in a travel-associated transmission cluster Disappearance of antibodies to SARS-associated coronavirus after recovery Effect of clinical and virological parameters on the level of neutralizing antibody against pandemic influenza A virus H1N1 Serologic responses of 42 MERS-coronavirus-infected patients according to the disease severity Effect of clinical and virological parameters on the level of neutralizing antibody against pandemic influenza A virus H1N1 Serologic responses of 42 MERS-coronavirus-infected patients according to the disease severity A serological survey on neutralizing antibody titer of SARS convalescent sera China puts 245 COVID-19 patients on Treatment of 5 Critically Ill Patients With COVID-19 With Convalescent Plasma The feasibility of convalescent plasma therapy in severe COVID-19 patients: a pilot study Deployment of convalescent plasma for the prevention and treatment of COVID-19 US Food & Drug Administration Development & Approval Process (CBER) Investigational COVID-19 Convalescent Plasma -Emergency Use of convalescent whole blood or plasma collected from patients recovered from Ebola virus disease for transfusion, as an empirical treatment during outbreaks Anti-severeacute respiratory syndrome coronavirus spike antibodies trigger infection of humanimmune cells via a pH-and cysteine protease-independent FcgammaR pathway Influence ofFcgammaRIIA and MBL polymorphisms on severe acute respiratory syndrome Current studies of convalescent plasma therapy for COVID-19 may underestimate risk of antibodydependentEnhancement Position paper" sulla produzione di plasma iperimmune da utilizzare nella terapia della malattia da SARS Effect of heat inactivation of blood samples on the efficacy of three detection methods of SARS-CoV-2 antibodies. Nan Fang Yi Ke Da Xue Xue Bao Hyperimmune Plasma for Critical Patients With COVID-19 (COV19 PLASMA Passive immunotherapy of viral infections: 'super-antibodies' enter the fray Legend to Figure 1 :Anti-SARS-CoV-2 hyperimmune plasma workflow Abbreviations:EUA-Emergency Use Authorization, CLIA-Clinical Laboratory Improvement Amendments, TRALI-Transfusion-Related Acute Lung Injury, ADE-antibody dependent enhancement All Authors declare no organizations that funded our research, including grant numbers.J o u r n a l P r e -p r o o f J o u r n a l P r e -p r o o f CP-Convalescent plasma TRALI-Transfusion related acute lung injury ELISA-Enzyme Linked Immunosorbent Antibody assay PRNT-plaque reduction neutralization assay IFA-Indirect fluorescent antibody testing MN-Microneutralization assay.