key: cord-0897762-wptc95qb
authors: Wang, Maopeng; Fu, Tingting; Hao, Jiayi; Li, Letian; Tian, Mingyao; Jin, Ningyi; Ren, Linzhu; Li, Chang
title: A recombinant Lactobacillus plantarum strain expressing the spike protein of SARS-CoV-2
date: 2020-05-30
journal: Int J Biol Macromol
DOI: 10.1016/j.ijbiomac.2020.05.239
sha: f6199e2ee9e77a17cdd0ce9bc10792324bab9d8d
doc_id: 897762
cord_uid: wptc95qb

Coronavirus disease 2019 (COVID-19), which is caused by severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2), has become a global pandemic in the past four months and causes respiratory disease in humans of almost all ages. Although several drugs have been announced to be partially effective treatments for this disease, no approved vaccine is available. Here, we described the construction of a recombinant Lactobacillus plantarum strain expressing the SARS-CoV-2 spike protein. The results showed that the spike gene with optimized codons could be efficiently expressed on the surface of recombinant L. plantarum and exhibited high antigenicity. The highest protein yield was obtained under the following conditions: cells were induced with 50 ng/mL SppIP at 37 °C for 6–10 h. The recombinant spike (S) protein was stable under normal conditions and at 50 °C, pH = 1.5, or a high salt concentration. Recombinant L. plantarum may provide a promising food-grade oral vaccine candidate against SARS-CoV-2 infection.

Coronavirus disease 2019 (COVID-19) has become a pandemic over the past five months, with 4,962,707 confirmed cases and 326,459 deaths reported in more than 215 countries, areas, or territories by 22 May 2020.

The pathogen of this disease is a newly identified virus, designated severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2), which has high identity with bat SARS-CoV [1, 2] . The virus belongs to the β-coronavirus genus and contains a positive-sense single-stranded RNA genome, which encodes at least 4 structural proteins and 7 nonstructural proteins [1, 2] . Among the viral proteins, the spike (S) protein is located on the viral surface and can bind to the cell-surface receptor angiotensin-converting enzyme 2 (ACE2) for entry and interact with the cellular serine protease TMPRSS2 for S protein priming [2, 3] . Moreover, other groups have reported that the S protein can also recognize cellular CD147 (also known as Basigin or EMMPRIN) [4] and AGTR2 (angiotensin II receptor type 2) [5] for entry into human cells. These results indicate that the S protein serves as the main target of antibodies.

Lactic acid bacteria have become a potential oral bacterial vector to deliver DNA and proteins, as they are normally present in the intestine of humans and most animals and play beneficial roles in various gastrointestinal and inflammatory disorders [6] [7] [8] [9] [10] [11] . Lactic acid bacteria are usually safe and stable in human gastrointestinal conditions, with relatively strong tolerance of gastric acid and bile salt, and can adhere well to colonic epithelial cells [12] [13] [14] . These bacteria also inhibit the adherence and growth of pathogens and induce cytokines [12] [13] [14] . Among lactic acid bacteria, Lactobacillus plantarum is widely recognized as a probiotic that can be used in food fermentation, vaccines and medicine [12] [13] [14] [15] [16] [17] [18] . Our previous studies also showed that L. plantarum CGMCC 1.557 (named Lp18 J o u r n a l P r e -p r o o f 4 by our laboratory) is a promising probiotic strain due to its high adhesion to intestinal cells, strong anti-inflammatory and immunoregulatory functions [13, 14, 17, 18] . Here, we report the construction and optimization of L. plantarum expression system for the SARS-CoV-2 S protein.

The Lactococcus lactis strain NZ3900 was previously purchased from MoBiTec GmbH (Goettingen, Germany) and grown in M17 medium (Difco, USA) supplemented with 0.5 % glucose (GM17 medium) at 30 °C [11] .

Lactobacillus plantarum CGMCC 1.557 (Lp18) was purchased from the Institute of Microbiology, Chinese Academy of Sciences. Lp18 was grown in MRS medium (Merck, Darmstadt, Germany) at 37 °C [11] .

The codons of the spike gene from the SARS-CoV-2 isolate Wuhan-Hu-1 (GenBank: MN908947) were optimized according to the codon usage bias of Lp18. Then, the optimized S gene, named tS, was synthesized and linked with the sequence of the endogenous signal peptide 1320 (ALX04_001320) of L. plantarum at the 5' terminus and the target peptide D (DCpep: FYPSYHSTPQRP) and HA genes at the 3' terminus of the tS gene. Subsequently, the fragment, designated 1320-tSDH, was amplified using the primers F01 and R01 and subcloned into pSIP411 (a gift from Qi) with Nco I and Xba I using the Gibson Assembly ® Cloning Kit (NEB, USA) according to the manufacturer's instructions, producing the expression plasmid pLP-tS. Then, the plasmid was J o u r n a l P r e -p r o o f 5 electrotransformed into competent L. lactis NZ3900 cells as described previously [11] . A positive colony was selected on a GM17 agar plate containing 10 μg/mL erythromycin (Sigma, USA) and verified by colony PCR using the primers F01 and R01, followed by sequencing analysis.

Competent Lp18 cells were prepared according to a protocol described previously [11] . Briefly, precultured Lp18 cells were cultured in MRS medium containing 2 % glucose at 37 °C. When the OD600 reached 0.3-0.5, the cells were centrifuged at 10,000 × g for 10 min and washed with ddH2O (distilled water) three times, followed by centrifugation at 10,000 × g for 2 min. Then, the cells were resuspended in precooled electroporation buffer. Thereafter, 1 μg expression plasmid pLP-tS was incubated with 40 μL competent cells on ice for 20 min and electrotransformed into the competent cells in a 0.2-cm BTX cuvette by a single pulse with an apparatus (BTX) set at 1.75 kV and 5 ms.

Then, the cells were plated on an MRS agar plate containing 10 μg/mL erythromycin (Sigma, USA) at 37 °C for 24-48 h. The positive colony, designated Lp18:S, was verified by colony PCR using the primers F01 and R01 and sequencing analysis.

One milliliter of precultured Lp18:S cells was mixed with 100 mL MRS medium containing 10 μg/mL erythromycin, induced with SppIP (50 ng/mL, final concentration, Genscript, China) until the culture reached an OD600 of 0.3-0.5 and further cultured at 37 °C for 7-8 h. Then, the cells were centrifuged at 10,000 × g for 2 min, washed with PBS twice, and lysed with 0.1 μm zirconia beads (1:3, Biospec, USA). The lysates were incubated with 5× loading buffer, boiled in a water bath for 5 min and evaluated by J o u r n a l P r e -p r o o f 6 Western blot analysis.

Cell lysates obtained as described above were separated using 12 % SDS-PAGE and transferred onto a PVDF membrane (Millipore, USA). Then, the membrane was incubated with PBST containing 5 % skim milk for 2 h at room temperature, followed by incubation with a primary antibody (anti-HA tag rabbit polyclonal antibody, 1:2,000, Proteintech, USA; anti-S1 rabbit monoclonal antibody, 1:500, Future Biotech, China; or anti-RBD mouse monoclonal antibody 13E10D5, 1:1,000, Genscript, China) at 4 °C overnight and four washes with TBST. Thereafter, the membrane was reacted with an HRP-conjugated goat anti-rabbit IgG (H+L) (1:10,000, Zsbio, China) or HRP-conjugated goat anti-mouse IgG (H+L) secondary antibody (1:5,000, Bioss, China) at room temperature for 1 h and washed with PBST four times. Subsequently, the bands were visualized with ECL reagent (Thermo Fisher Scientific, USA).

Lp18:S cells were cultured in MRS for 12 h, washed with PBS twice, and collected by centrifugation at 8,000 × g for 2 min. The pellet was mixed with a primary antibody 

Lp18:S and Lp18 cells were induced with SppIP, collected, and washed with pure water twice by centrifuging for 10 min at 12,000 × g. Then, the cells were negative stained with 2 % phosphotungstic acid (PTA, Sigma, USA) for 2 min. Subsequently, the samples were examined using a Hitachi-7650 transmission electron microscope with 150-mesh Formvar grids at an accelerating voltage of 90 kV.

Lp18:S and Lp18 cells were induced with SppIP for 8 h, collected by centrifugation at 5,000 × g for 10 min and washed with PBS twice. The pellets were incubated with a primary antibody (anti-HA tag rabbit polyclonal antibody, 1:100, Proteintech, USA) at 4 °C overnight, followed by three washes with PBS. Then, the cells were incubated with a secondary antibody (FITC-conjugated goat anti-rabbit IgG, 1:3,000, Zsbio, China) for 40 min at room temperature. After washing with PBS twice, the samples were examined using a flow cytometer. 

Statistical analysis was performed using GraphPad 6.0. Data are presented as the mean ± standard deviation (SD) of at least three replicates. P<0.05 was considered to indicate a statistically significant difference between groups. Experiments were repeated at least three times.

Lactic acid bacteria are food-grade bacteria that are widely used for expressing target antigens in vaccine development [6] [7] [8] [9] [10] [11] . However, the expression efficiency of a target protein may be affected by the codon usage bias of the bacteria chosen [11, 19] . terminus of the gene, resulting in a fragment named 1320-tSDH. Then, the fragment was amplified using the primers F01 and R01 and subcloned into pSIP411 with Nco I and Xba I using the Gibson Assembly ® Cloning Kit (NEB, USA), producing the expression plasmid pLP-tS. Thereafter, the expression plasmid was electrotransformed into competent Lp18 cells as described previously [11] . A positive colony, designated L.

plantarum Lp18:S, was grown and verified by colony PCR using the primers F01 and R01 and sequencing analysis (Fig. 1A) . To evaluate the expression of the S protein in the recombinant strain, Lp18:S cells were induced with SppIP (50 ng/mL, final concentration), and the levels of the S protein were analyzed by Western blot analysis. As shown in Fig. 1B, a 150 -kD band could be detected using an anti-HA tag rabbit polyclonal antibody, an anti-S1 rabbit monoclonal antibody or anti-RBD mouse monoclonal antibody 13E10D5 as the primary antibody, indicating that the codon-optimized S protein was successfully expressed in the L.

plantarum Lp18:S strain. Furthermore, both Lp18:S cells and Lp18 cells were examined using a transmission electron microscope (TEM) and an indirect immunofluorescence assay (IFA). The results showed that the morphology of the bacteria was not affected by the viral S protein, while numerous filamentous proteins were present on the surface of the recombinant bacteria Lp18:S (Fig. 1C) and exhibited high-efficiency reactivity (Fig.   1D ). In addition, the positive rates of the bacteria expressing the S protein induced by SppIP were analyzed by flow cytometry. The results showed that the positive rate of S protein expression in recombinant Lp18 was approximately 37.5 %, while it was 2.5 % in the parental strain (Fig. 1D) . These results suggest that the viral S protein can be efficiently displayed on the surface of the recombinant L. plantarum Lp18:S strain, which can be used for further research. Fig. 1 HERE. 

Previously, we found that relatively high expression yields for proteins can be achieved by optimizing the parameters of the expression system [11] . Therefore, recombinant L. plantarum Lp18:S was optimized for induction time (2 to 22 h), inducer concentration (10, 50, 100, and 150 ng/mL) and bacterial passage (passage 1 to 10). As J o u r n a l P r e -p r o o f shown in Fig. 2A , the levels of the S protein were significantly enhanced in the SppIP-induced group compared with the other groups. The highest levels of the S protein were obtained by induction with up to 50 ng/mL SppIP for 8 h at 30 °C ( Fig.   2B-C) . In addition, the passage of bacteria, at least in the first 5 passages, had no significant effect on protein expression. As the passage number increased, it was difficult to maintain a consistent inoculation amount. Due to different induction states, some changes occurred. However, there were still sufficient amounts of protein specifically detected by Western blot analysis (Fig. 2D) .

To evaluate the stability of the recombinant protein, Lp18:S cells were induced with SppIP for 8 h, followed by treatment at different temperatures (37 or 50 ℃) for 20 min, different pH values (pH=1.5 or 7) for 30 min, or different bile salt concentrations (0, 0.2 or 0.5 %) for 2 h. The results showed that the recombinant S protein was stable at 50 °C for 20 min or pH=1.5 for 30 min, with no significant differences between the normal group and the treated group (Fig. 2E-F) . Moreover, the level of the S protein was significantly increased in the bacteria treated with 0.2 % bile salt compared with the bacteria treated with the other bile sale concentrations (Fig. 2G) . These results suggest that the recombinant S protein expressed in the L. plantarum system is stable in an environment with a high temperature, acidity, and bile salt concentration. Therefore, L. plantarum expressing the recombinant S protein may be used orally as a food-grade vaccine. Fig. 2 HERE. J o u r n a l P r e -p r o o f

To date, no effective medicines or approved vaccines are available for COVID-19.

Although several groups have reported the development of inactivated vaccines, subunit vaccines or mRNA-based vaccines for SARS-CoV-2 virus infection [20] [21] [22] , most of these vaccines are in clinical trials and are generally provided by injection. Notably, the use of these vaccines is expensive and complicated, requiring professional administration.

However, oral vaccines are cost effective, easy to administer, easy to store, and widely accepted to be biofriendly [23] [24] [25] . Moreover, it has been reported that oral vaccines induce strong antigen-specific IgG responses, mucosal IgA responses, and Th1/Th17 responses [26] [27] [28] , thus reducing or preventing the infection and replication of viruses in the respiratory tract and intestinal mucosa. Therefore, the development of an effective oral vaccine for COVID-19 is still urgently needed.

In recent years, lactic acid bacteria, as food-grade bacteria, have been widely used for expressing target antigens in oral vaccines [6-11, 27, 28] . Furthermore, antigens displayed on the surface of L. plantarum can induce a significant immune response and provide efficient protection against infection [27, 28] . In this study, we constructed a recombinant L. plantarum Lp18:S strain expressing the S protein of SARS-CoV-2 via Gibson assembly and homologous recombination. We previously found that codon optimization could improve the expression level of a target protein and a target peptide could enhance the transport of the target protein to the cell surface [11] . Therefore, to enhance expression efficiency, codons of the S protein were optimized according to the codon usage bias of L. plantarum, and both a target peptide and an endogenous signal peptide were linked at the 3' terminus and 5' terminus of the S protein, respectively. The results demonstrated that the S protein could be efficiently displayed on the bacterial J o u r n a l P r e -p r o o f 12 surface, forming a large number of irregularly folded peptide chains, and exhibit high reactivities with a rabbit polyclonal antibody (anti-HA tag) and SARS-CoV-2 spike-specific monoclonal antibodies (Fig. 1) .

For oral vaccines, the stability of the antigen protein is important. Therefore, we analyzed the stability of the S protein expressed on the surface of the bacteria. The results showed that the antigenic protein had the characteristics of thermal stability and acid stability and that the expression level was obviously increased in the presence of 0.2 % bile salt (Fig. 2) , suggesting that recombinant L. plantarum Lp18:S can be used as an oral vaccine against SARS-CoV-2 infection.

Middle East respiratory syndrome (MERS) spike proteins may trigger antibody-dependent enhancement (ADE) but not alter the expression profile of proinflammatory genes in human macrophages [29] [30] [31] . However, Lou et al. found that low levels of antibodies induced by an inactivated SARS-CoV vaccine might not induce ADE in rhesus macaques [32] . Similarly, whether SARS-CoV-2-specific vaccines can induce ADE is also controversial [33] [34] [35] [36] . Encouragingly, Qin and colleagues reported that a purified inactivated SARS-CoV-2 vaccine could induce SARS-CoV-2-specific neutralizing antibodies in mice, rats and nonhuman primates, providing effective protection against SARS-CoV-2 challenge in macaques without observable ADE effects [35] . Therefore, whether oral vaccines developed with the recombinant L. plantarum strain created in this study can induce ADE will be further evaluated in animal models and human clinical trials in subsequent studies. Further studies are in progress to analyze the feasibility, safety, and efficacy of recombinant L. plantarum as a practical oral vaccine in vivo.

J o u r n a l P r e -p r o o f 13 

In conclusion, we constructed a recombinant L. plantarum strain expressing the S protein of SARS-CoV-2, which could be efficiently displayed on the bacterial surface with high stability at 50 °C for 20 min or pH=1.5 for 30 min. The highest levels of the S protein were obtained by treatment with 50 ng/mL SppIP and 0.2 % bile salt for 8 h at 30 °C.

Recombinant L. plantarum Lp18:S is a potential mucosal vaccine candidate tolerant to gastrointestinal conditions.

The datasets used and/or analyzed during the current study are available from the corresponding author on reasonable request. 

Genetic evolution analysis of 2019 novel coronavirus and coronavirus from other species

A pneumonia outbreak associated with a new coronavirus of probable bat origin

SARS-CoV-2 Cell Entry Depends on ACE2 and TMPRSS2 and Is Blocked by a Clinically Proven Protease Inhibitor

SARS-CoV-2 invades host cells via a novel route

One Possible Novel Key Gene for the Entry of 2019-nCoV into Human Cells

Oral immunization with recombinant lactobacillus plantarum induces a protective immune response in mice with Lyme disease

Recombinant Lactobacillus johnsonii as a mucosal vaccine delivery vehicle

Lactobacillus plantarum vaccine vector expressing hemagglutinin provides protection against H9N2 challenge infection

A dendritic cell targeted vaccine induces long-term HIV-specific immunity within the gastrointestinal tract

Dendritic cell-targeted recombinantLactobacilli induce DC activation and elicit specific immune responses against G57 genotype of avian H9N2 influenza virus infection

Construction and optimization of Lactobacillus plantarum expression system expressing glycoprotein 5 of porcine reproductive and respiratory syndrome virus

Suitability of Lactobacillus plantarum SPC-SNU 72-2 as a Probiotic Starter for Sourdough Fermentation

Inhibition of Staphylococcus aureus adherence to Caco-2 cells by lactobacilli and cell surface properties that influence attachment

Evaluation of immunomodulatory activity of two potential probiotic Lactobacillus strains by in vivo tests

Lactobacillus plantarum and Its Probiotic and Food Potentialities

New perspectives of Lactobacillus plantarum as a probiotic: The gut-heart-brain axis

In vitro evaluation of the probiotic and functional potential of Lactobacillus strains isolated from fermented food and human intestine

Lactobacilli reduce chemokine IL-8 production in response to TNF-alpha and Salmonella challenge of Caco-2 cells

Codon bias and heterologous protein expression

Development of a COVID-19 vaccine based on the receptor binding domain displayed on virus-like particles, bioRxiv

An Evidence Based Perspective on mRNA-SARS-CoV-2 Vaccine Development

Role of oral vaccines as an edible tool to prevent infectious diseases

Edible vaccine success

Edible vaccines: current status and future

Oral immunization of mice with a multivalent therapeutic subunit vaccine protects against Helicobacter pylori infection

Oral Immunization of Chickens With Recombinant Lactobacillus plantarum

Proof of concept in utilizing in-trans surface display system of Lactobacillus plantarum as mucosal tuberculosis vaccine via oral administration in mice

Antibody-dependent SARS coronavirus infection is mediated by antibodies against spike proteins

Antibody-dependent enhancement of SARS coronavirus infection and its role in the pathogenesis of SARS

Evaluation of Antibody-Dependent Enhancement of SARS-CoV Infection in Rhesus Macaques Immunized with an Inactivated SARS-CoV Vaccine

Is COVID-19 receiving ADE from other coronaviruses?

Is antibody-dependent enhancement playing a role in COVID-19 pathogenesis?

Avoiding pitfalls in the pursuit of a COVID-19 vaccine

Author statement Conceptualization: Ningyi Jin; Methodology: Maopeng Wang, Tingting Fu; Formal analysis: Jiayi Hao; Validation: Letian Li; Data Curation

Writing -Original Draft: Linzhu Ren and Maopeng Wang; Writing -Review & Editing: Linzhu Ren and Chang Li; Funding acquisition