key: cord-0004161-heo6mtxk authors: Stoian, Ana M.M.; Zimmerman, Jeff; Ji, Ju; Hefley, Trevor J.; Dee, Scott; Diel, Diego G.; Rowland, Raymond R.R.; Niederwerder, Megan C. title: Half-Life of African Swine Fever Virus in Shipped Feed date: 2019-12-03 journal: Emerg Infect Dis DOI: 10.3201/eid2512.191002 sha: d84f1c9036052ca0d9f8216cac4c5118ad8cea19 doc_id: 4161 cord_uid: heo6mtxk African swine fever virus is transmissible through animal consumption of contaminated feed. To determine virus survival during transoceanic shipping, we calculated the half-life of the virus in 9 feed ingredients exposed to 30-day shipment conditions. Half-lives ranged from 9.6 to 14.2 days, indicating that the feed matrix environment promotes virus stability. However, half-life calculations were based on the limited data available at the time, including 2 time points representing inoculation dose and titers at the conclusion of the study and insufficient replicates from which to calculate SEs or 95% CIs around the half-life estimates. For this study, our objective was to improve the accuracy of ASFV half-life estimates by increasing the number of time points and replicates in the same trans-Atlantic model. We used 9 feeds or feed ingredients for this study. We programmed an environmental chamber with the environmental conditions of humidity and temperature, which fluctuated every 6 hours, over a 30-day simulated trans-Atlantic shipment (11) . We added 5 g of each gamma-irradiated feed ingredient to 50-mL conical tubes before inoculating them with 100 µL of 10 5 50% tissue culture infective dose (TCID 50 ) of ASFV. We used ASFV Georgia 2007/1 (12) because of its similarity to currently circulating isolates (3) . Negative controls consisted of complete feed samples in meal form with 100 µL of sterile phosphate-buffered saline (PBS) added. Positive controls consisted of 5 mL of RPMI 1640 medium (Gibco, https://www.thermofisher. com) lacking feed with 100 µL of 10 5 TCID 50 ASFV. After addition of virus or PBS, we vortexed samples for 10 s and covered each tube with a vented cap for incubation. After removing the samples from the environmental chamber, we added 15 mL of sterile PBS and replaced the vented caps with solid caps. We organized samples in duplicate into 4 replicate batches representing 4 time points and simulated the trans-Atlantic shipping model over 2 separate 30-day periods. We used 144 titrations for the half-life calculations in feed (4 time points × 4 replicates = 16 titers/feed ingredient) and duplicate titers over 4 time points to calculate half-life in RPMI medium. We tested samples for ASFV on days 1, 8, 17, and 30 after contamination. The first sample was collected at 1 day after contamination to allow the virus to stabilize within each matrix. ASFV was quantified by virus titration as described previously (5) . We vortexed samples for 10 s and then centrifuged at 10,000 × g for 5 min at 4°C. Supernatant from each sample was stored at −80°C. We collected porcine alveolar macrophages for virus isolation by lung lavage of 3-5-week-old pigs and cultured for 1 day in RPMI medium supplemented with 10% fetal bovine serum and antibiotics Emerging in a 37°C 5% CO 2 incubator. We prepared 2-fold serial dilutions in RPMI medium in triplicate, added dilutions to monolayers of porcine alveolar macrophages in 96-well plates, and incubated for 1 h at 37°C. Cells were washed again and RPMI medium replaced. After 4 days at 37°C, the cells were fixed with 80% acetone for 10 min and stained with mouse anti-p30 primary monoclonal antibody (1:6,000 dilution). We incubated plates at 37°C for 1 h and washed 3 times with PBS before addition of goat anti-mouse Alexa Fluor 488 secondary antibody (Invitrogen, https://www. thermofisher.com; 1:400 dilution), followed by 1-h incubation at 37°C. We viewed cells under a fluorescence microscope and calculated the log 10 TCID 50 /mL according to the Spearman-Karber method (13) . For all sample types, we calculated the half-life and corresponding 95% CI. The half-life analysis was performed by fitting a linear regression model to the data by using R version 3.5.2 (https://www.r-project.org), with the natural log of the virus endpoint titers as the response variables and time as the explanatory variables. We estimated the slope and SE of the respective lines by using these regression models and half-lives calculated as −log e (2)/slope as previously described (14) . We calculated the SE for each half-life by multiplying the SE of the slope by log(2) divided by the square of the slope. We calculated the upper and lower bounds of the 95% CI as the estimated half-life plus/ minus the product of the SE times the critical value of a t distribution with quantile as 0.025 and degrees of freedom as n -2, where n is the sample size for that ingredient (14) . Environmental conditions during the course of the trans-Atlantic model (Figure, panel A) were a mean + SD temperature of 12.3 ± 4.7°C (range 0-26°C) and a mean + SD humidity of 74.1% ± 19.2% (range 20%-100%). Negative control samples remained negative. All ASFVinoculated samples showed detectable quantities of infectious ASFV (Figure, panel B) . The half-life estimate in the RPMI-positive control was shorter than that for all feed ingredients tested: 8.3 + 0.3 days (95% CI 7.7-9.0 days) ( Feed ingredients were inoculated with 10 5 TCID 50 ASFV based on previous half-life calculations (5, 10) and the infectious dose in feed (6) . TCID 50 , 50% tissue culture infective dose. soybean meal) and 12.9 + 0.6 days (organic soybean meal). The relative stability in feed may be the result of variable protein, fat, or moisture content among ingredients. Overall, the mean half-life for ASFV in all animal feed ingredients was 12.2 days. Although the high stability of ASFV in contaminated pork products and blood has been appreciated for decades (15) , the stability of ASFV in plant-based feed has been recognized only recently (5) . Our previous estimation of the half-life of ASFV in feed ingredients was based on the limited data we had available, including inoculation dose and 18 titers quantified at 1 time point during the 30-day model (5, 10) . In this study, we quantified viral decay at several time points over the 30-day model and increased sample size, which enabled us to calculate SEs and 95% CIs around the half-life estimates. In general, this updated modeling approach resulted in longer half-life estimates across all matrices. This study provides quantitative data on the half-life of ASFV Georgia 2007 in animal feed ingredients exposed to moderate temperature and humidity conditions simulating transoceanic shipment. The longer virus half-lives in feed compared with half-lives in media support the concept that the feed matrix provides an environment that increases ASFV stability. Furthermore, these data provide additional evidence supporting the ability of plant-based feed ingredients to promote survival of ASFV should these products become contaminated. Comparative analysis of whole-genome sequence of African swine fever virus Belgium 2018/1 Outbreak of African swine fever Emergence of African swine fever in China Swine enteric coronavirus disease: a review of 4 years with porcine epidemic diarrhoea virus and porcine deltacoronavirus in the United States and Canada Survival of viral pathogens in animal feed ingredients under transboundary shipping models Infectious dose of African swine fever virus when consumed naturally in liquid or feed African swine fever spread in China African swine fever virus introduction into the EU in 2014: experience of Latvia Genome sequences derived from pig and dried blood pig feed samples provide important insights into the transmission of African swine fever virus in China Correction: survival of viral pathogens in animal feed ingredients under transboundary shipping models Correction: survival of viral pathogens in animal feed ingredients under transboundary shipping models African swine fever virus isolate Statistical method in biological assay The use of half-lives and associated confidence intervals in biological research Is there a risk for introducing porcine reproductive and respiratory syndrome virus (PRRSV) through the legal importation of pork? We thank the staff of the Biosecurity Research Institute and Maureen Sheahan for their assistance in the Biosafety Level 3 laboratory. We acknowledge the Kansas State University Applied Swine Nutrition team for their past contributions to the area of feed risk. The ASFV Georgia 2007/1 isolate was kindly provided by Linda Dixon at the Pirbright Institute and obtained through the generosity of David Williams at the Commonwealth Scientific and Industrial Research Organization's Australian Animal Health Laboratory.Funding for this study was provided by the Swine Health Information Center (grant no. 17-189) and the State of Kansas National Bio and Agro-Defense Facility Fund. Ms. Stoian is a PhD student in the College of Veterinary Medicine at Kansas State University, Manhattan, Kansas. Her research is focused on understanding virus replication in gene-edited animals and on feed biosecurity for prevention and control of foreign and endemic infectious diseases.